Product ID:DC6571-805 HIGH HEAT ALUMINUM, 500A16
MSDS Date:05/01/1995
FSC:8010
NIIN:00N085077
MSDS Number: CGZXT

GRIGGS PAINT

3602 S 16TH PL
PHOENIX, AZ 85040
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 602-243-3293

Preparer: ROBERT COMMISSO

Cage: DO312

GRIGGS PAINT

PHOENIX, AZ 85040-1319 US

Telephone: 602-243-3293

Cage: DO312

15 @

CAS: 64742-89-8

Fraction By Weight: 13%

OSHA PEL N/K

ACGIH TLV: N/K

STODDARD SOLVENT; (ALIPHATIC HYDROCARBONS (STODDARD TYPE)).

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 29%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

ALUMINUM; (ALUMINUM FLAKE) (SARA 313)

CAS: 7429-90-5

RTECS: BD0330000

Fraction By Weight: 30%

OSHA PEL 15 MG/M3 DUST

ACGIH TLV: 10 MG/M3 DUST

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: BREATHING HIGH
CONCENTRATIONS OF VAPORS MAY LEAD TO LUNG CHANGES, NAUSEA,
VOMITING, COUGH, PULMONARY IRRITATION AND CENTRAL NERVOUS SYSTEM
DEPRESSION. MAY CAUSE DROWSINESS, DIZZINESS, FATI GUE FOLLOWED BY
COMA. EYES: DIRECT CONTACT AND/OR CONTACT WITH VAPORS MAY CAUSE
IRRITATION. SKIN: (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ: PRLNGD/RPTD CONTACT MAY CAUSE
IRRITATION AND/OR DERMATITIS. MAY BE ABSORBED THROUGH THE SKIN WITH
MODERAL IRRITATION, DEFATTING AND DERMATITIS. INGESTION: ASPIRATION
OF THIS PRODUCT INTO THE LUNGS MAY CAUSE PNEUMONITIS,
PULMONARYEDEMA AND HEMORRHAGE. INGESTION MAY CAUSE GI DISTRUBANCES.
THIS PRODUCT (SUPDAT)
Medical Cond Aggravated by Exposure:INDIVIDUALS WITH PRE-EXISTING
DISEASES IN OR HISTORY OF AILMENTS INVOLVING SKIN, CENTRAL NERVOUS
SYSTEM, LIVER AND KIDNEY.

First Aid:INHAL: REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE
OXYGEN/ARTIFICIAL RESPIRATION) . EYES: IMMEDIATELY FLUSH W/LARGE
AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. SEEK MEDICAL AID. SKIN:
WASH THOROU GHLY W/SOAP & WATER. SEEK MEDICAL AID IF IRRITATION
PERSISTS. INGEST: IMMEDIATELY SEEK MEDICAL AID. DO NOT INDUCE
VOMITING. DO NOT ATTEMPT TO GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON.

Flash Point Method:TCC
Flash Point:50.0F,10.0C
Lower Limits:0.9%
Upper Limits:7.0%
Extinguishing Media:FOAM, CARBON DIOXIDE, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH APPRVD SCBA & FULL PROTECTIVE EQUIP
. WATER MAY BE INEFFECTIVE. WATER MAY BE USED TO COOL CNTNRS. IF
WATER IS USED, FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE
FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN FLAME. CLOSED
CONTAINERS MAY EXPLODE WHEN EXPOSED TO HEAT.

Spill Release Procedures:STOP LEAK IF NO RISK INVOLVED. REMOVE ALL
SOURCES OF IGNITION. STAY UPWIND. ABSORB WITH INERT MATERIAL. FLUSH
AREA WITH WATER. VENTILATE AREA FOR AT LEAST 24 HOURS OR UNTIL AREA
HAS BEEN DECLARED SAFE .
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP CONTAINERS CLOSED & UPRIGHT TO
PREVENT LEAKAGE. AVOID FLAMES, WELDING, OPEN LIGHTS, ETC. AVOID
BRTHG VAP & SPRAY MIST. AVOID SKIN & EYE CONTACT.
Other Precautions:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREAS, TANK OR PIT WITHOUT ADEQUATE VENTILATION.

Respiratory Protection:IF VENT DOES NOT MAINTAIN INHAL EXPOS BELOW TLV
(PEL), USE NIOSH APPRVD UNITS. USE UNITS PER CURRENT 29 CFR
1910.134 & FOLLOW MFR'S INSTRUCTIONS & WARNINGS. IF W/IN OSHA PROT
FACTOR, NIOSH APPRVD AIR PURIFYING OV/FILTER UNITS OK FOR USE.
Ventilation:LOCAL AND MECHANICAL EXHAUST.
Protective Gloves:RUBBER GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGLES .
Other Protective Equipment:ANSI APPROVED EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:MAINTAIN GOOD PERSONAL HYGIENE. DO NOT USE IN
CONFINED AREA WITHOUT ADEQUATE VENTILATION.
Supplemental Safety and Health
EFTS OF OVEREXP: CONTAINS CHEMICALS KNOWN TO STATE OF CALIFORNIA TO
CAUSE CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.

Boiling Pt:B.P. Text:>260F,>127C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1.0 (H*2O=1)
VOC Grams/Liter:4.21
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:ESSENTIALLY NIL
Appearance and Odor:VISCOUS LIQUID WITH TYPICAL PAINT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:FLAMES, SPARKS, SMOKING AND HEAT.
Hazardous Decomposition Products:CARBON MONOXIDE AND CARBON DIOXIDE.

Waste Disposal Methods:USE INERT ABSORBENT MATERIALS ON SPILLS. DISPOSE
OF IN ACCORDANCE WITH ALL FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.